Product ID:ACETIC ACID, GLACIAL, 9508
MSDS Date:08/16/1996
FSC:6810
NIIN:01-061-8236
MSDS Number: CFQXH

JT BAKER INC

222 RED SCHOOL LN
PHILLIPSBURG, NJ 08865
US

Emergency Phone: 908-859-2151;800-424-9300(CHEMTREC)

Info Phone: 800-424-8802

Cage: 4W981

MALLINCKRODT BAKER, INC.

PHILLIPSBURG, NJ 08865 US

Telephone: 800-582-2537

Cage: 70829

ACETIC ACID (CERCLA)

CAS: 64-19-7

RTECS: AF1225000

Fraction By Weight: 99-100%

OSHA PEL 10 PPM

ACGIH TLV: 10 PPM; 15 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

BY SEPARATING W/FINGERS. OBTAIN MED ATTN W/OUT

RTECS: 9999999ZZ

FROM SPILL AREA. FLUSH AREA WITH WATER. PREVENT

RTECS: 9999999ZZ

FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

LD50 LC50 Mixture:LD50 (ORAL, RAT): 3310 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: SEV IRRIT/BURNS OF RESP
SYS, PULM EDEMA, LUNG INFLAMM, HEADACHE, COUGHING, DFCLT BREATHING,
DIZZINESS, CHEST PAINS, TEETH DAMAGE, RESP FAILURE. SKIN CONT: SEV
BURNS, MAY OCCUR, DERMATITI S. EYE CONT: SEV BURNS, PERMANENT EYE
DAMAGE. SKIN ABSORPTION: NONE IDENTIFIED. INGEST: BURNS TO MOUTH
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:AND THROAT, NAUSEA, VOMITING,
GASTROINTESTINAL IRRIATION, DIARRHEA, SHOCK, MAY BE FATAL. CHRONIC
EFFECTS: LUNG DAMAGE, TEETH DAMAGE. TARGET ORGANS: RESPIRATORY
TRACT, EYES, SKIN, TEETH.
Medical Cond Aggravated by Exposure:RESPIRATORY SYSTEM DISEASE, SKIN
DISORDERS.

First Aid:INGEST: CALL MD. DO NOT INDUCE VOMIT. IF CONSCIOUS, GIVE
H*2O, MILK, OR MILK OF MAGNESIA. INHAL: REMOVE TO FRESH AIR. IF NOT
BRTHG, GIVE ARTIFICIAL RESP. IF BRTHG IS DFCLT, GIVE OXYG. PROMPT
ACTION IS ESSENTIAL. SKIN CONT: IMMED FLUSH W/PLENTY OF H*2O FOR @
LST 15 MINS WHILE REMOVING CONTAMD CLTHG AND SHOES. WASH CLTHG
BEFORE RE-USE. EYE CONT: IMMED FLUSH, INCLUDING UNDER EYELIDS W/LRG
(SUP DAT)

Flash Point Method:CC
Flash Point:103F,39C
Lower Limits:4.0%
Upper Limits:19.9%
Extinguishing Media:USE WATER SPRAY, ALCOHOL FOAM, DRY CHEMICAL OR
CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . MOVE CNTNRS FROM FIRE AREA IF IT CAN BE DONE W/OUT
RISK. USE H*2O TO KEEP FIRE-EXPOSED CNTRS COOL.
Unusual Fire/Explosion Hazard:VAPORS MAY FLOW ALONG SURFACES TO DISTANT
IGNIT SOURCES & FLASH BACK. CLSD CNTNRS EXPOSED TO HEAT MAY
EXPLODE. CONT W/STRONG OXIDIZERS MAY CAUSE FIRE. (SUP DAT)

Spill Release Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT CLTHG. SHUT
OFF IGNIT SOURCES; NO FLARES, SMKNG/FLAMES IN AREA. STOP LEAK IF
YOU CAN DO W/OUT RISK. NEUT SPILL W/SODA ASH/LIME. W/CLEAN SHOVEL,
CAREFULLY PLACE MATL INTO CLEAN, DRY CNTNR & COVER. REMOVE (ING 3)
Neutralizing Agent:SODA ASH OR LIME.

Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLSD. STORE IN
COOL, DRY, WELL-VENT, FLAM LIQ STOR AREA/CABINET. STORE >17C. AVOID
BRTHG VAPORS.
Other Precautions:KEEP AWAY FROM HEAT, SPKS, FLAME. DO NOT GET IN EYES,
ON SKIN, ON CLTHG. USE W/ADEQ VENT.

Respiratory Protection:RESP PROTECTION REQ IF AIRBORNE CONC EXCEEDS
TLV. AT CONCS UP TO 500 PPM, A NIOSH APPRVD CHEM CARTRIDGE RESP
W/ACID/ORGANIC CARTRIDGE TYPE IS RECOMMENDED. ABOVE THIS LEVEL, A
NIOSH APPRVD SELF-CONTAIN ED BREATHING APPARATUS IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGG & (ING 4)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
UNIFORM, PROTECTIVE SUIT.
Work Hygienic Practices:WASH THROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH:2.4 (1.0M SOLN). EXPLO HAZ:REACTS W/MOST METALS TO PRDCE HYDROGEN
GAS, WHICH CAN FORM AN EXPLO MIX W/AIR. MATL TO AVOID:HYDROGEN
PEROXIDE, ALKALIES, CARBONATES, STRONG BASES, AMINES, PHOSPHORUS
TRI CHLORIDE, PHOSPHORUS PENTACHLORIDE. FIRST AID:AMTS OF H*2O FOR
@ LST 15 MINS. ASSURE ADEQ FLUSHING OF THE EYES (ING 2)

Boiling Pt:B.P. Text:244F,118C
Melt/Freeze Pt:M.P/F.P Text:62.0F,16.7C
Vapor Pres:11 @ 20C
Vapor Density:2.1
Spec Gravity:1.05 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:0.97 (BUTYL ACETATE = 1)
Solubility in Water:COMPLETE (100%)
Appearance and Odor:COLORLESS LIQUID. VINEGAR-LIKE ODOR.
Percent Volatiles by Volume:100%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, MOST COMMON METALS (EXCEPT ALUMINUM), CHROMIC
ACID, NITRIC ACID, SULFURIC ACID, (SUPDAT)
Stability Condition to Avoid:HEAT, FLAME, OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ACETIC ACID.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.